2004 Toyota Avalon
    MSRP
    $26,145 - $30,605
    Advertisement

    2004 Toyota Avalon Recalls

    NHTSA Campaign ID #

    14V147000

    Recall Date

    2014-03-27

    Summary

    Toyota is recalling certain model year 2003-2004 Avalon vehicles manufactured June 5, 2002, through December 20, 2004. In these vehicles, the supplemental restraint system (SRS) circuits are susceptible to internal shorting. The electrical short may create an abnormal current flow and increased heat which can damage the circuits. This could result in an inadvertent deployment of the front air bags and/or seat belt pretensioners.

    Consequences

    Inadvertent deployment of the air bags or the seat belt pretensioners increases the risk of an injury or crash.

    Remedy

    Toyota will notify owners and dealers will install a noise filter between the air bag control module and the wire harness, free of charge. The manufacturer mailed interim owner notification letters on May 5, 2014. The remedy letter was mailed to owners on October 1, 2014. Owners may contact Toyota at 1-800-331-4331.

    Component Affected

    AIR BAGS

    Notes

    Toyota Motor Corporation

    NHTSA Campaign ID #

    11V539000

    Recall Date

    2011-11-09

    Summary

    TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004 AVALON VEHICLES; 2004 AND 2005 CAMRY, CAMRY SOLARA, HIGHLANDER, AND SIENNA VEHICLES, 2006 HIGHLANDER HYBRID; 2004 AND 2005 LEXUS ES330 AND RX330; AND 2006 LEXUS RX400H VEHICLES MANUFACTURED FROM JUNE 1, 2004 THROUGH MARCH 31, 2005, EQUIPPED WITH THE 1MZ-FE OR 3MZ-FE ENGINE. THE AMOUNT OF ADHESIVE AGENT APPLIED BETWEEN THE OUTER RING AND THE TORSIONAL RUBBER DAMPER (INNER RING) IN THE CRANKSHAFT PULLEY MAY BE INADEQUATE. IF THE ADHESIVE IS INSUFFICIENT, THERE IS A POSSIBILITY THAT THE OUTER RING MAY BECOME MISALIGNED AND IT MAY NOT PROPERLY ROTATE WITH THE INNER RING, CAUSING NOISE AND/OR ILLUMINATION OF THE BATTERY DISCHARGE INDICATOR LIGHT.

    Consequences

    IN SOME CASES, THE BELT FOR THE POWER STEERING PUMP MAY BECOME DETACHED FROM THE PULLEY WHICH COULD RESULT IN A LOSS OF POWER STEERING AND A SUDDEN INCREASE IN STEERING EFFORT, INCREASING THE RISK OF A CRASH.

    Remedy

    TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL CHECK THE CRANKSHAFT PULLEY TO IDENTIFY WHETHER IT WAS PRODUCED BY THE U.S. SUPPLIER. IF SO, THE DEALER WILL REPLACE THE PULLEY WITH A NEW ONE AT NO CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING EARLY JANUARY 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

    Component Affected

    ENGINE AND ENGINE COOLING

    Notes

    Toyota Motor Corporation

    NHTSA Campaign ID #

    10V345000

    Recall Date

    2010-07-29

    Summary

    TOYOTA IS RECALLING CERTAIN MODEL YEAR 2000-2004 AVALON VEHICLES. DUE TO IMPROPER CASTING OF THE STEERING LOCK BAR, THERE IS A POSSIBILITY THAT A MINUTE CRACK MAY DEVELOP ON THE SURFACE OF THE LOCK BAR. SUCH A CRACK MAY EXPAND OVER A LONG PERIOD OF REPEATED LOCK AND UNLOCK OPERATIONS, AND EVENTUALLY THE LOCK BAR COULD BREAK.

    Consequences

    SHOULD THE STEERING LOCK BAR BREAK, THE STEERING WHEEL WOULD LOCK AND THE DRIVER WOULD LOSE THE ABILITY TO STEER THE VEHICLE, INCREASING THE RISK OF A CRASH.

    Remedy

    DEALERS WILL REPLACE THE STEERING INTERLOCK DEVICE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 7, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

    Component Affected

    STEERING

    Notes

    Toyota Motor Corporation

    *The data and content on this web site is subject to change without notice. Neither AOL nor any of its data or content providers shall be liable for errors in the content, or for any actions taken in reliance thereon.

    Powered by
    View recall reports to see if the was recalled for safety-related defects or non-compliance with U.S. safety standards.
    Best Deal:
    Our Price:
    Savings:
    MSRP:
    Go Back to Best Deals »